Abstract. In this work, sources of iron-containing waste in Uzbekistan, their current processing technologies, iron oxide recovery methods and analysis of the main parameters of the process, areas of application of iron powder, requirements, brands, classifications of iron powder, working conditions of the experiment, CM using hydrogen gas 1.6 The parameters of thermal treatment in a 5-zone furnace, the results of X-ray fluorescent analyzer analysis of experimentally obtained samples, and the discussion of the analysis result are given. In the study, comparing the duration of the main parameters reduction and oxidation, it was found that both conversion rates at low temperatures are lower than at high temperatures for several cycles. At 800 °C cycle-to-cycle reduction times increased by about 2.2% and oxidation times by about 11%, while at 850 °C, reduction times increased by about 3% and oxidation times by about 4.5% per cycle. At 900 °C, however, the loss of reactivity in the cycle was only 1% for reduction and less than 1% for oxidation.
References:
1. P. Wang, M. Ryberg, Y. Yang, K. Feng, S. Kara, M. Hauschild, W.-Q. Chen. Efficiency stagnation in global steel production urges joint supply- and demandside mitigation efforts, Nat. Commun. (2021), https://doi.org/10.1038/ s41467-021-22245-6.
2. Otto, M. Robinius, T. Grube, S. Schiebahn, A. Praktiknjo, D. Stolten. Power-tosteel: reducing CO2 through the integration ofrenewable energy and hydrogen into the German steel industry, Energies (2017), https://doi.org/10.3390/en10040451.
3. Clean circles, accessed 02 June (2023), https://www.tu-darmstadt.de/cleancircles/about_cc/index.en.jsp.
4. C. Hessels, T. Homan, N. Deen, Y. Tang. Reduction kinetics of combusted iron powder using hydrogen, Powder Technol. (2022), https://doi.org/10.1016/j.powtec.
5. G. Jannach, G. Krammer, G. Staudinger, K. Friedrich. Hydrogen From Biomass Gasification for Fuel Cell System by Application of the Sponge Iron Oxide Process Cycle, Technische Universitat¨ Graz, (2016)
6. E. Schurmann. Die Grundlagen der Reduktionsvorgange in: ¨ Physikalische Chemie der Eisen- und Stahlerzeugung, Vortrage einer ¨ vom Verein Deutscher Eisenhuttenleute durchgefuhrten Bericht- ¨ sreihe; Herausgegeben vom Verein Deutscher Eisenhuttenleute; (1964). Ver- ¨ lag Stahleisen, Dusseldorf.
7. V. Hacker, G. Faleschini, H. Fuchs, R. Fankhauser, G. Simader, M. Ghaemi, B. Spreitz, K. Friedrich. Usage of biomass gas for fuel cells by the SIR process, J. Power Sources 71 (1998)
8. Heinzel. Fuel Cell Demands, JOR3-CT96-105, 2nd periodic report, (1997).
9. K. Kordesch, G. Simader. Einsatz der Brennstoffzellentechnologie fur die Verwendung von technischen Gasen aus Abfallholz, project ¨ study at the Institute for Chemical Technology of Inorganic Compounds, University of Technology Graz, (1993).
10. .J. Heizmann, P. Becker, R. Baro. Kinetik und Strukturumwandlung bei der Reduktion von Hamatit in Magnetit, Arch. Eisenhuttenwes (1974) .
11. P. Hartner. Entwicklung eines Computerprogrammes zur eindimensionalen Simulation von heterogenen Festbett und Vorschubreaktoren, Thesis, Technical University Graz, (1996).
12. G. Krammer, G. Staudinger, J. Wurzenberger. Simulation der Eisenschwamm-Reaktoren, Internal report, EU-Project, Technical University Graz, (1999)
13. Shamatov, Sirojiddin Abdijalil Ugli, and Ilkhom Uralbai Ugli Rakhmanov. " OBTAINING SODIUM SULPHATE AND IRON OXIDE PIGMENT BASED ON IRON SULPHATE."Oriental renaissance: Innovative, educational, natural and social sciences (2021)
14. Eshchenko, Lyudmila Semenovna, R. A. Vorontsov, and I. U. Rakhmanov. "Preparation of ferroferrioxides as magnetic powders based on iron sulfate." Chemical Technology and Engineering (2020).
15. Рахманов, И. У. "Получение сульфата калия на основе железного купороса" (2020).
16. Boltayev, Olmos. " TECHNOLOGY OF SEPARATION OF IRON OXIDE FROM IRON STORAGE WASTE OBTAINED AS A RESULT OF FLOTATION ENRICHMENT OF COPPER Slag." Eurasian Journal of Academic Research (2022).
17. Rakhmanov, I. U., V. V. Klimovich, and D. V. Gaiduk. "Study of the composition and properties of intermediate and final products in the system FeSO [4]–H [2] SO [4]–KOH–H [2] O." (2020).
18. Khudoykulov, R. B., and I. U. Rakhmanov. "THE INFLUENCE OF MECHANICAL ACTIVATION ON THE COMPOSITION OF PRODUCTS OF ALKALINE CONVERSION OF IRON (II) SULPHATE." POLISH SCIENCE JOURNAL (2021)
19. Aripova, M. "MODERN METHODS FOR PROCESSING IRON-CONTAINING TECHNOGENIC WASTE (TAILS) OF COPPER PRODUCTION." Science and innovation 2.A10 (2023).
20. Shamshidinov, A. Kambarov, R. Najmiddinov, I. Rustamov, I. Usmanov, M. Samadiy. Study of Physico-Chemical Properties of Phosphorate Solutions. E3S Web Conf (2023).
SCIENCE & INNOVATION